ТИТУЛЬНЫЕ СТРАНИЦЫ
СОДЕРЖАНИЕ
CONTENT
ПОДЗЕМНАЯ РАЗРАБОТКА МЕСТОРОЖДЕНИЙ
UNDERGROUND MINING
АТРУШКЕВИЧ В.А., ПЕПЕЛЕВ Р.Г., КАРАСЕВ Г.А.
ДВУХСТАДИЙНЫЙ ВЫПУСК РУДЫ ПРИ ОТРАБОТКЕ НАКЛОННЫХ ЗАЛЕЖЕЙ
Рассмотрена
и обоснована эффективность перехода с торцевого выпуска руды к донному
при разработке наклонных залежей за счет снижения потерь и разубоживания
руды. Предлагаемый вариант системы разработки предполагает подэтажную
отбойку и частичный выпуск отбитой руды с последующим переходом на
выпуск основных отбитых запасов по всей площади наклонного днища с
соблюдением равномерно-последовательного режима выпуска. Нетрадиционный
подход к проблеме максимального излечения руды в относительно дешевых
системах с массовым обрушением совместил донную и торцевую схемы выпуска
рудной массы в условиях отработки наклонных залежей. Ожидаемый уровень
потерь и разубоживания дает возможность эффективно отработать запасы
полезного ископаемого.
Ключевые слова: подземная разработка
руд, системы разработки с обрушением руды и вмещающих пород, донный
выпуск, торцевой выпуск, отбойка в зажиме, частичный выпуск, массовый
выпуск, потери руды, разубоживание руды.
ATRUSHKEVICH V.A., PEPELEV R.G., KARASEV G.A.
TWO-STAGE ORE DISCHARGE IN PITCHING ORE BODIES
Considered
and substantiated the effectiveness of the transition from the
mechanical release of ore to the bottom in developing inclined deposits
by reducing losses and dilution of ore. Proposed by the authors version
of the system development involves the breaking of sublevel and partial
release of a broken ore before proceeding to the main issue rescued
reserves throughout the area in compliance with the inclined bottom
uniformly consistent mode of manufacture.
An unconventional approach
to maximizing the recovery of ore at a relatively low cost systems with
massive collapse combined ground and short circuit of mining in deep
inclined weight of the deposits. The expected level of dilution and
losses gives the opportunity to effectively practice the mineral
reserves.
Key words: underground mining ore development system
with the collapse of the ore and host rocks, bottom release end issue,
breaking the clip, partial release, mass production, the loss of ore,
ore dilution.
ЕРЕМЕНКО А.А., АЛЕКСАНДРОВ А.Н., КУЛИКОВ В.И., СПУНГИН В.Г.
ИССЛЕДОВАНИЕ ИНТЕНСИВНОСТИ СЕЙСМИЧЕСКОГО ДЕЙСТВИЯ МАССОВОГО ВЗРЫВА ПРИ ОТРАБОТКЕ СЛЕПОГО РУДНОГО ТЕЛА
Представлены
результаты измерений сейсмического действия массового взрыва при
отработке слепого рудного тела. Определены максимальные скорости
колебания почвы в районе взрыва и балльность.
Ключевые слова: массовый взрыв, рудное тело, кровля и почва, крепость руды, система разработки.
EREMENKO A.A., ALEKSANDROV A.N., KULIKOV V.I., SPUNGIN V.G.
INTENSITY OF SEISMIC EFFECT PRODUCED BY LARGE-SCALE BLASTING IN A BLIND OREBODY MINING
The
article presents measurement data on the large-scale blast-induced load
exerted on the blind orebody in Tashatgol Mine. The authors have
estimated the influence of explosive charge weight on the rock mass
vibration velocity, showed the seismic effect produced by the
large-scale blasting on the guarded objects in the mine and on the
buildings of the township above ground. The identified spacing of the
blast source and a guarded object and the rock mass seismicity
coefficients will enable evaluation of seismic impact on environment due
to blasting.
Key words: large-scale blast, orebody, roof, floor, ore hardness, mining method.
КАЗАНИН О.И., ЛЕ ВАН ХАУ
CОСТОЯНИЕ И ПЕРСПЕКТИВЫ РАЗВИТИЯ ТЕХНОЛОГИИ ПОДЗЕМНОЙ ДОБЫЧИ УГЛЯ В БАССЕЙНЕ КУАНГНИНЬ ВЬЕТНАМА
Представлены
сведения о запасах угля, условиям залегания и планам развития
угледобычи в бассейне Куангнинь Вьетнама. На основе анализа опыта
отработки угольных пластов показаны основные направления развития
технологии подземной добычи угля в бассейне.
Ключевые слова: уголь, подземная добыча, технология, перспективы развития, Вьетнам.
KAZANIN O.I., LE VAN HAU
STATEMENT AND PERSPECTIVES OF THE UNDERGROUND COAL MINING TECHNOLOGY DEVELOPMENT AT QUANG NINH COAL BASIN OF VIETNAM
The
information about coal reserves, geological conditions and coal mining
development perspectives at the Quang Ninh coal basin of Vietnam are
given. The basin is largest in Vietnam and because of depth of mining
increasing the underground coal mining is most perspective mining
method. It is shown that for most part of coal resources the geological
conditions are suitable for using modern longwall equipment. The
comparising estimation of economical indicators of blasting and
mechanizing mining method at basin coal mines has shown the advantages
of mechanized mining in providing mining efficiency and safety. On the
bases of coal mining experience and mining equipment analyses as main
trends of the underground coal mining technology development in basin
are determined: continuing of using mining technologies which allready
proved their efficiency, implementing modern longwall equipment
complexes for middle and thick coal seams with inclination up to 450,
modernization of Vinacomin machinery plants for producing modern mining
equipment in Vietnam. The underlighted trends must be taken into
consideration during new coal mines projects development.
Key words: coal, underground mining, technology, development perspectives, Vietnam.
КАЗАНИН О.И., НОРВАТОВ Ю.А., ЧЕРКАШИН А.А., САВЕЛЬЕВ Д.И.
АНАЛИЗ ОПЫТА ИНТЕНСИВНОЙ ОТРАБОТКИ ВЫЕМОЧНЫХ УЧАСТКОВ НА ШАХТЕ КОТИНСКАЯ ОАО «СУЭК-КУЗБАСС» В УСЛОВИЯХ ПОВЫШЕННЫХ ВОДОПРИТОКОВ
На
основе анализа опыта отработки шести выемочных участков по пласту 52 в
условиях шахты «Котинская» ОАО «СУЭК-Кузбасс» за пятилетний период
определены факторы, ограничивающие технико-экономические показатели
работы очистных забоев. Отмечена низкая адаптационная способность
применяемой технологии к увеличению притоков воды на выемочные участки.
Приведены сведения о применявшихся мерах по управлению состоянием
массива с целью снижения водопритоков. Показано, что экспериментальное
использование заградительного дренажа в условиях шахты «Котинская» не
дало положительного эффекта. На основе разработанных геофильтрационных
моделей выполнен прогноз водопритоков при развитии горных работ на
шахте.
Ключевые слова: угольный пласт, выемочный участок, интенсивная разработка, влияющие факторы, водоприток.
KAZANIN O.I., NORVATOV YU.A., CHERKASHIN А.А., SAVELIEV D.I.
ANALYSIS OF INTENSIVE LONGWALL PANELS MINING AT KOTINSKAYA MINE JSC «SUEK-KUZBASS» IN THE CONDITIONS OF HIGH WATER INFLOWS
The
article includes analysis of the seam 52 six longwall panels mining
experience during five-year period in the conditions of Kotinskaya mine
of JSC SUEK-Kuzbass. The main factors which limited the technical and
economical indicators of longwalls were determined. It was determined
that the main reason, which cause the longwall productivity decreasing
was the high water inflow (more than 700 m3/h) at the
longwall panels.High water inflows leads to increasing longwall
productive time losses and its productiveness decrease and economical
losses as a consequence. The low adaptive ability of applied mining
technology to water inflows increasing is indicated. The information
about rock mass condition control measures used at the mine to decrease
water inflow is given. It was shown that boarding drainage in Kotinskaya
mine conditions was ineffective. On the bases of developed
geofiltrational models the water inflows forecast during mining
development was made. As the streams of mining technology improvement in
condition of 900-1200 m3/h water inflows are determined:
longwall panel orientation with the angle to inclination line to provide
natural water outcome as well as development additional panel drainage
entries.
Key words: coal seam, longwall panel, intensive mining, influencing factors, water inflow.
ЛОМОНОСОВ Г.Г.
О НЕСООТВЕТСТВИИ МЕЖДУ ОПРЕДЕЛЕНИЕМ И ТОЛКОВАНИЕМ ТЕРМИНА «СИСТЕМА ПОДЗЕМНОЙ РАЗРАБОТКИ РУДНОГО МЕСТОРОЖДЕНИЯ»
Рассмотрен
вопрос совершенствования горно-технической терминологии. В частности,
несоответствие между определением термина «система подземной разработки
рудного месторождения» и его пониманием, в результате чего на практике
фактически происходит подмена одного термина «способ выполнения очистных
работ» другим («система подземной разработки»).
Автор рассматривает свою статью как предмет для обсуждения специалистами горно-рудного дела.
Ключевые слова: система (разработки), рудные месторождения, порядок (разработки),
особенности (рудных месторождений), классификационный признак.
LOMONOSOV G.G.
IMBALANCE BETWEEN THE DEFINITION AND INTERPRETATION OF THE TERM «UNDERGROUND ORE MINING METHOD»
The
author addresses the issue of the mine engineering terminology
refining. In particular, the inconsistency of definition and
understanding of the term «underground ore mining method» results in its
replacement by the other term, namely, «stoping method».
The author offers the article subject for discussion by experts in ore mining.
Key words: mining method, ore deposits, mining sequence, ore deposit features, classification criterion.
ПОСТНИКОВ В.И., ТКАЧ В.Р., АГАФОНОВ В.В., БЕЛЯЕВ В.В.
ВЫЯВЛЕНИЕ ВЗАИМО-ОБУСЛОВЛЕННЫХ ЭЛЕМЕНТОВ ПРОГРЕССИВНОСТИ И ЭКОНОМИЧНОСТИ ТЕХНОЛОГИИ ПОДЗЕМНОЙ ДОБЫЧИ УГЛЯ
Приведены
основные аспекты системной интерпретации оценки прогрессивности и
экономичности ведения подземных горных работ. Выявлен приоритет задачи
количественной оценки всех условий работы шахт, их технико-экономической
эффективности, качества вскрытия и подготовки шахтных и выемочных
полей, прогрессивности технического уровня очистных и подготовительных
работ, транспорта-подъема, проветривания шахтных и выемочных полей,
технологического комплекса поверхности с одновременной оценкой
обобщающего технического уровня шахты и результативности
научно-технического прогресса, экологического состояния шахт.
Ключевые слова: подземная угледобыча, системная оценка, прогрессивность, экономичность, качество, квалиметрия, интегральная оценка.
POSTNIKOV V.I., TKACH V.R., AGAFONOV V.D., BELYAEV V.V.
IDENTIFICATION OF INTERDEPENDENT ELEMENTS OF PROGRESSIVE AND ECONOMICAL TECHNOLOGY OF UNDERGROUND COAL MINING
The
article presents the main aspects of the interpretation of evaluation
system progressivity and efficiency of underground mining. Identified
priority tasks to quantify all the conditions of the mines, their
technical and economic efficiency, quality and training of the mine
opening and excavation of fields, advanced technical level of clearing
and preparatory works, transport, lifting, ventilation and mine
excavation of fields, technological complex surfaces with simultaneous
evaluation synthesis technical level of the mine and refine scientific
and technical progress, the ecological state of the mines. The first
element of the calculation reveals comparatively favorable conditions
and workability of coal mine — the second element to the assessment
shows how the results of the comparative lead this work — the third
element specifies how quality indicators affect opening and preparation
of mining and excavation of fields on the manufacturability of their
development, — the fourth element reveals the influence of the basic
processes of coal mining on the formation of technical and economic
efficiency — the fifth element reveals the influence of scientific and
technological progress in general the technology of underground coal
mining — the sixth element evaluates the effectiveness of technological
schemes of mining operations from the standpoint of gas and
geomechanical hazards forms an idea of systemic involvement in shaping
the security level of a mountain, technical or organizational factors —
the seventh element of assessing the impact of negative environmental
components of mechanical mining, hydro, gas-dynamic and radiative
processes of underground and surface atmospheric process necessary and
appropriate mine closure.
Key words: underground coal mining, system evaluation, progressiveness, efficiency, quality, qualimetry, integral evaluation.
ОБОГАЩЕНИЕ ПОЛЕЗНЫХ ИСКОПАЕМЫХ
ENRICHMENT OF MINERALS
ВОЛОВИКОВ А.Ю., ШАРИКОВ Ю.В.
ВЛИЯНИЕ ОТДЕЛЬНЫХ ФЛОТАЦИОННЫХ РЕАГЕНТОВ НА ЗАСОРЕНИЕ МАТЕРИАЛА КЕРАМИЧЕСКИХ ВАКУУМНЫХ ДИСКОВЫХ ФИЛЬТРОВ
Описаны
результаты исследования влияния разных типов флотационных реагентов на
материал керамических вакуумных дисковых фильтров при обезвоживании
железорудного концентрата. Характер влияния суспензии на керамический
материал фильтра представлен для флотационных реагентов, а именно,
коллектора, двух видов депрессоров, вспенивателя, а также для
трансмиссионного масла, как возможной примеси, попадающей в суспензию в
ходе технологического цикла. Определены значения параметра,
характеризующего скорость засорения фильтрующей перегородки для каждого
реагента. Представлены результаты анализа керамического материала с
применением сканирующего электронного микроскопа. Сделаны выводы о
необходимости удаления того или иного реагента из суспензии перед
обезвоживанием.
Ключевые слова: флотационные реагенты, железорудный концентрат, керамический фильтр.
VOLOVIKOV A.YU., SHARIKOV YU.V.
INFLUENCE OF FLOTATION REAGENTS ON CERAMIC VACUUM DISC FILTERS
The
article describes the results of studies into effect exerted by
various-kind flotation reagents on ceramic vacuum disk filters used in
dewatering of iron ore concentrate. The impact of the suspension on the
filter ceramics material is illustrated for a collector, two types of
depressor, frother, and gear oil as an optional admixture than can enter
suspension in the course of the process circuit. The parameter
characterizing the filter clogging rate is evaluated for each kind of
reagents. The electron scanning microscopy analysis of the ceramic
material is presented. Finally, it is deduced if it is necessary or not
to remove this or that reagent from suspension before dewatering
process.
Key words: flotation reagents, iron ore, ceramic medium.
ВОЛОВИКОВ А.Ю., ШАРИКОВ Ю.В.
РАЗРАБОТКА МАТЕМАТИЧЕСКОЙ МОДЕЛИ ЗАСОРЕНИЯ КЕРАМИЧЕСКИХ ВАКУУМНЫХ ДИСКОВЫХ ФИЛЬТРОВ ПРИ ОБЕЗВОЖИВАНИИ ЖЕЛЕЗОРУДНОГО КОНЦЕНТРАТА
Описаны
принципы разработки математической модели процесса засорения фильтра
при разделении суспензии железорудного концентрата с применением
дисковых вакуумных фильтров. Подробно представлены этапы разработки
модели и анализа данных, полученных при варьируемых оперативных
параметрах работы экспериментальной установки. Определен вид наиболее
информативных зависимостей, с точки зрения сбора и дальнейшего анализа
данных о процессе. Определен общий вид зависимости величины собственного
удельного сопротивления фильтрующей перегородки от времени для
суспензии и материала фильтра, образующих систему, характеризующуюся
набором уникальных параметров.
Ключевые слова: засорение, железорудный концентрат, сопротивление фильтра.
VOLOVIKOV A.YU., SHARIKOV YU.V.
DEVELOPMENT OF FOULING MODEL FOR IRON ORE FILTRATION BY VACUUM DISC FILTERS
The
article describes principles of mathematical modeling of filter
clogging during separation of iron ore concentrate using disc vacuum
filters. The modeling stages and the analysis of data obtained with
varied operating parameters of the experimental plant are specified. The
type of relationships to be most informative from the viewpoint of data
acquisition and processing is defined. The general form of the relation
between the filter membrane background resistivity and the time is
determined for the suspension and the filter material that arrange a
system characterized by a set of the unique parameters.
Key words: iron ore, filter fouling, medium resistance.
ДВОЙЧЕНКОВА Г.П., КОВАЛЕНКО Е.Г., КОМАРОВА Н.И.
МОДЕЛИРОВАНИЕ
И ИССЛЕДОВАНИЕ ПОВЕРХНОСТНЫХ СВОЙСТВ АЛМАЗОВ ПРИ ИСПОЛЬЗОВАНИИ
ЭЛЕКТРОХИМИЧЕСКИ МОДИФИЦИРОВАННЫХ МИНЕРАЛИЗОВАННЫХ ВОД
Представлены
результаты моделирования и исследования процессов образования и
растворения пленок нерастворимых соединений на природно измененных
алмазах. Показано, что жидкая фаза пульпы в основных технологических
процессах склонна к протеканию процессов осадкообразования и
кристаллизации нерастворимых соединений непосредственно на поверхности
алмазов.
В результате проведенных теоретических и экспериментальных
исследований обосновано и подтверждена эффективность применения
электрохимического кондиционирования оборотных вод в циклах липкостной и
пенной сепараций для повышения извлечения алмазов, подверженных
интенсивным поверхностным изменениям.
Ключевые слова: алмазосодержащие руды, мелкие классы алмазов, оборотные воды, карбонатизация, гидрофилизующие пленки, пенная сепарация.
DVOJCHENKOVA G.P., KOVALENKO E.G., KOMAROVA N.I.
MODELING AND INVESTIGATION OF SURFACE PROPERTIES OF DIAMONDS FROM THE USE OF MODIFIED ELECTROCHEMICALLY MINERALIZED WATERS
The
results of modeling and studying the formation and dissolution of
insoluble compounds films on modified natural diamonds. It has been
shown that the liquid phase of the pulp in the main processes tends to
leak precipitation and crystallization processes insoluble compounds
directly onto the surface of diamond. The results showed that the highly
mineralized undivided electrochemical treatment process water can
decrease the concentration of calcium ions and the total carbon dioxide,
which reduces the tendency to sediment loading. As a result of
theoretical and experimental research is justified and confirmed the
effectiveness of electrochemical conditioning circulating water cycles
adhesion and foam separation and to improve recovery of diamonds subject
to heavy surface changes.
Key words: diamond ores, small classes of diamonds, circulating water, carbonation, hydrophilic films, foam separation.
КОЗЛОВ В.А., ЧЕРНЫШОВА Е.Н.
РАБОТА ТЯЖЕЛОСРЕДНОГО ГИДРОЦИКЛОНА БОЛЬШОГО ДИАМЕТРА В УСЛОВИЯХ НИЗКОЙ ПЛОТНОСТИ РАЗДЕЛЕНИЯ И ТРУДНОЙ ОБОГАТИМОСТИ УГЛЯ
Представлены
основные результаты работы в рамках проекта № С20045 Австралийской
Угольной Исследовательской Программы (ACARP), являющегося этапом 2 и
продолжающим этап 1 — проект ACARP № 17036. Главной целью было
исследование работы тяжелосредного гидроциклона (ТСГЦ) большого диаметра
1450 мм в критических режимах для получения данных об условиях, при
которых работа гидроциклона начинает отклоняться от допустимой. Для
нахождения условий, в которых работа ТСГЦ начала бы ухудшаться,
исследовались изменения нагрузки по твердому в питании, соотношения
суспензии и угля (М:С) в диапазоне от 3:1 до 6:1, давление на входе в
гидроциклон от 5D до 9D. Проводилась сепарация при низкой плотности
разделения и при очень трудной обогатимости угля (критерий Бэрда ±0.1RD =
42%). Для нахождения пределов эффективности разделения тонких частиц
проводилась оценка, учитывающая присутствие немагнитного материала в
образцах магнетитовой суспензии. Итоги этой оценки показали, что схожая
эффективность работы достигается как в случае двух циклонов меньшего
диаметра, так и в случае одного гидроциклона большого диаметра при
высокой плотности разделения и легкой обогатимости угля. Работа
гидроциклона начинала ухудшаться только при размере частиц меньше 1,0
мм, что позволило определить «критический» размер угольных частиц.
Ключевые слова: тяжелосредный гидроциклон, плотность разделения, погрешность
разделения, критерий обогатимости, магнетитовая суспензия, критический
размер частиц угля.
KOZLOV V.A., CHERNYSHOVA E.N.
OPERATION OF A LARGE-DIAMETER FLOAT-AND-SINK CYCLONE IN THE CONDITIONS OF LOW DENSITY SEPARATION AND LOW WASHABILITY OF COAL
The
article reports the results of the Australian Coal Industry's Research
Program project С20045, Stage 2, to continue Stage 1 project ACARP №
17036. The objective was the analysis of operation of a float-and-sink
cyclone (FSC) with large diameter of 1450 mm under critical duties, to
obtain the data on the conditions of out-of-reliability operation of the
machine. Aimed at identifying conditions of FSC performance
degradation, the operation analysis involved varied solid loading in the
feed of the cyclone, varied pulp-to-coal ratio in the range from 3:1 to
6:1, the cyclone inlet pressure ranged from 5D to 9D. Separation was
carried out at low density and low washability of coal (Bard criterion ±
0.1RD = 42%). Definition of the efficient separation limits for fine
particles accounted for nonmagnetic materials present in magnetite pulp
specimens. By the resultant estimations, the operation efficiency is
equal in case of two smaller-diameter cyclones and in case of one
large-diameter cyclone given the high density separation and high
washability of coal. The cyclone performance started degrading with coal
particles smaller than 1.0 mm, which identified the «critical» size of
coal particles.
Key words: float-and-sink cyclone, density of
separation, error of separation, washability criterion, magnetite pulp,
critical size of coal particles.
КОРНИЛОВ С.Н., МЕЛЬНИКОВ И.Т., ПЫТАЛЕВ И.А., ПАВЛОВА Е.В., СУРОВ А.И.
ОБОСНОВАНИЕ ПАРАМЕТРОВ ГОРНОТЕХНИЧЕСКИХ СООРУЖЕНИЙ ДЛЯ РАЗМЕЩЕНИЯ ОТХОДОВ ОБОГАЩЕНИЯ
Приведена
методика расчета оптимальных параметров горнотехнических сооружений,
учитывающая площадь и форму их основания в плане, а также степени
обводненности приоткосного массива. Приведены формулы для определения
объема отвала в общем случае, для земельного отвода многоугольной формы.
Для фигур неправильной формы коэффициенты приближенно рассчитываются
как для эллиптической формы, с большой и малой полуосями. При
проектировании накопительных горнотехнических сооружений возможно
определить неограниченное количество их конфигураций, различающихся
формой в плане и по высоте. Обязательным при этом является обеспечение
нормативного коэффициента запаса устойчивости.
Выполненный анализ по
разработанной методике показал, что наибольшая емкость намывных
горнотехнических сооружений на заданной площади земельного отвода
достигается при круглой, квадратной или близкой к ним формах; при
увеличении площади земельного отвода оптимальный угол внешнего откоса
уменьшается, а высота сооружения возрастает; вместимость земельного
отвода зависит от его формы.
Ключевые слова: параметр, отвал, высота, емкость, откос, отход.
KORNILOV S.N., MEL'NIKOV I.T., PYTALEV I.A., PAVLOVA E.V., SUROV A.I.
RATIONALE FOR THE PARAMETERS OF FACILITIES FOR PLACEMENT MONTAN TAILINGS
The
author describes the calculation procedure for the parameters of
mine-technical structures, taking into account the structure bottom area
and shape in plan view, and the water content of the banking wall
rocks. The formulas to find volume of a banking in a general case and in
case of a polygonal land allotment for the banking are given. The
coefficients of irregular shape figures are calculated in the same way
as for elliptical shape figures with major and minor semi-axes. It is
possible to calculate unlimited number of shapes, varied laterally and
up/down, when designing storage mine-technical structures. In this case,
the provision of the rated stability factor is a must.
According to
the analysis performed using the proposed procedure, the largest volume
of the hydraulic fill banks at the assigned-area land allotment is
achieved with the banks of round or square, or close to these, shapes;
on the increase in the land allotment, the optimized angle of the outer
slope is decreased and the bank height is increased; the capacity of the
land allotment depends on its shape. At the round land allotment 400 ha
in area, given the assigned properties of rocks meant for the banking
and its bottom, the mine-technical structure capacity will amount to
381.2 Mm3; the same area allotment of the triangular shape will have
capacity of 245.8 Mm3, which is 30% less than in the former case. When
designing a cascaded hydraulic fill structure, the calculation of
optimal parameters of the structure should take into account the total
area of the land allotment rather than the areas of its separate
sections.
Key words: parameter, dump, height, volume, slope, waste.
НАУМОВ К.И., ШВЕДОВ И.М., МАЛОЛЕТНЕВ А.С.
ПРИМЕНЕНИЕ НОВЫХ ТЕХНОЛОГИЙ ДЛЯ ПОЛУЧЕНИЯ КОАГУЛЯНТА (СУЛЬФАТА АЛЮМИНИЯ) ИЗ УГЛЕОТХОДОВ
Приведены
результаты исследований по получению коагулянта (сульфата алюминия) для
очистки шахтных и сточных вод методом сернокислотного выщелачивания из
вскрышных пород Львовского участка угольного разреза Кимовский ОАО
«Тулауголь». Рассчитан материальный баланс производства 50 тыс.т
кристаллического сульфата алюминия в год, разработаны принципиальная
технологическая схема и аппаратурное оформление процесса для реализации в
промышленном масштабе.
Ключевые слова: отходы добычи и обогащения угля, сернокислотное выщелачивание.
NAUMOV K.I., SHVEDOV I.M., MALOLETNEV A.S.
APPLICATION OF NEW TECHNOLOGIES FOR COAGULANT (ALUMINUM SULFATE) FROM UGLEOTHODOV
The
results of research aimed at producing сoagulanta (aluminum sulfate) to
clean up the mine and waste water by sulfuric acid leaching of the
overburden of the L'viv region coal mine Kimovsk of OAO «Tulaugol».
Calcu-lated material balance for production of 50 tonnes of crystalline
aluminum sul-fate per year, developed process flow diagram and hardware
process for imple-mentation on an industrial scale.
Key words: coal extraction and washing waste, sulfuric-acid leaching.
ЧАНТУРИЯ Е.Л., ТОМСКАЯ Е.С.
ИНТЕНСИФИКАЦИЯ ПРОЦЕССА ФЛОТАЦИИ КВАРЦА ИЗ ЖЕЛЕЗИСТЫХ КВАРЦИТОВ С ИСПОЛЬЗОВАНИЕМ ЭЛЕКТРОХИМИЧЕСКОЙ ОБРАБОТКИ РЕАГЕНТОВ
Авторами
впервые исследована возможность повышения эффективности извлечения
кварца в пенный продукт электрохимически обработанным раствором
катионного собирателя амина в присутствии электрохимически обработанного
раствора жидкого стекла для активации поверхности кварца.
Ключевые слова: флотация, электрохимическая обработка, катионный собиратель, амин, кварц, железистые кварциты, жидкое стекло.
CHANTURIA E.L., TOMSKAYA E.S.
INTENSIFICATION FLOTATION OF QUARTZ OUT FERRUGINOUS QUARTZITE USING ELECTROCHEMICAL TREATMENT THE REAGENTS
Investigated
the possibility of increasing the efficiency of extraction of quartz in
foam after electrochemical treatment of solution cationic collector —
amine in the presence of sodium silicate solution after electrochemical
treatment to activate the surface of quartz.
Key words: flotation, electrochemical treatment, cationic collector, amine, quartz, ferruginous quartzite, sodium silicate.
МАРКШЕЙДЕРСКОЕ ДЕЛО
MARKSHADERING
ШПАКОВ П.С., ЮНАКОВ Ю.Л., РУДЕНКО В.В.
ИССЛЕДОВАНИЕ И ОБОСНОВАНИЕ ПАРАМЕТРОВ УСТОЙЧИВЫХ КАРЬЕРНЫХ ОТКОСОВ МЕСТОРОЖДЕНИЯ «ЭЛЬДОРАДО»
Рассматрены
вопросы, связанные с оценкой устойчивости северо-восточного и
юго-западного бортов карьера «Эльдорадо», анализ фактического состояния
откосов уступов и бортов карьера с оценкой их устойчивости, определение
физико-механических свойств и структурно-тектонических особенностей
горных пород, как основы для обоснования расчетных показателей свойств
пород прибортового массива карьера, расчет параметров устойчивых откосов
отвалов, уступов и бортов карьера.
Ключевые слова: карьер,
борт, уступ, откос, породы, прочность, трещиноватость, устойчивость,
поверхность скольжения, расчет, коэффициент устойчивости.
SHPAKOV P.S., JUNAKOV JU.L., RUDENKO V.V.
RESEARCH AND VALIDATION OF SUSTAINABILITY PARAMETERS QUARRY SLOPES DEPOSIT «ELDORADO»
The
problems associated with the assessment of stability of the
northeastern and southwestern pit «Eldorado», an analysis of the actual
state of the slopes and ledges pit. Shown that the construction of
non-working pit and their stability depends on the physico-mechanical
properties in the massif and fracture systems of various origins.
A
technique for the study of fracture tectonics field. The results of the
study of structural and tectonic features of the rock mass. Maps of
fracture career. The most dangerous of the fracture. An analysis of the
career field is divided into two sections (north-east, south-west ),
differing systems of influence of cracks on the slope stability. Shown
that the properties of the rocks have a very significant impact on
virtually all production processes in the development of oil fields.
Thorough and comprehensive study of the structure and the strength of
the rock mass should be preceded by addressing the prevention and
control of deformation phenomena in the quarries. Results of complex
studies to determine the physical and mechanical properties of rocks and
geotechnical soil elements. Substantiated physical and mechanical
characteristics of the calculated properties.
The methods for
calculating the stability program stability analysis and performance
calculations of limiting slope safety factor and geometric elements
needed to build the sliding surfaces corresponding limit equilibrium.
Results of calculations of the stability of pit ( the limit values ) for
all lines of exploration.
Key words: careers, board, shelf slope, rock strength, fracture, stability, sliding surface calculation, the stability coefficient.
СТРОИТЕЛЬСТВО ПОДЗЕМНЫХ СООРУЖЕНИЙ И ШАХТ
BUILDING OF UNDERGROUND CONSTRUCTIONS AND MINES
КОРЧАК А.В.
ПРОБЛЕМЫ, НАПРАВЛЕНИЯ И ПУТИ РЕШЕНИЯ ЗАДАЧ ОСВОЕНИЯ ПОДЗЕМНОГО ПРОСТРАНСТВА МЕГАПОЛИСОВ
Основополагающей
идеей освоения подземного пространства является принцип его
использования как видоизменяемого георесурса. Приводятся результаты
исследований по обоснованию методологических принципов проектирования,
строительства и эксплуатации подземных сооружений при освоении
подземного пространства Москвы.
Особенность предлагаемого подхода
состоит в том, что подземное сооружение рассматривается как один из
элементов сложной динамической природно-технической геосистемы
«массив-технология-подземное сооружение-окружающая среда».
Ключевые слова: георесурс, природно-техническая геосистема, экспертные системы, нормативно-правовая база.
KORCHAK A.V.
PROBLEMS, DIRECTIONS AND WAYS OF THE DECISION OF PROBLEMS OF TOWN-PLANNING DEVELOPMENT OF UNDERGROUND SPACE OF MEGACITY
The
study contains the results of research on the scientific substantiation
and creation of the methodological principles of construction designing
and reutilization of Moscow underground utilities in complicated mining
and geological conditions, based on the controlled technological
processes that provide for the development and protection of underground
space as an interchangeable geo-resource. The basic idea of the study
in the underground construction treated as an element of the unified
complicated man-caused geosystem «massif-technology-underground
utility», based on the dynamic interconnection of all elements allowing
to make forecast of the decision as well as to adequately react to
change of the man-caused and quaternary factors by the means of
operative requlation of the parameters of the technological process.
Key words: georesource, nature-and-industry geosystem, expert systems, regulatory and legal framework.
КУЛИКОВА Е.Ю.
СУЩНОСТЬ, ВИДЫ И ЦЕЛИ ЭКОЛОГИЧЕСКОГО АУДИТА В ГОРНОМ ДЕЛЕ
Рассмотрены
виды экологического аудита и его особенности в условиях
недропользования. Представлены основные этапы экологического и
геоэкологического аудирования горного предприятия. Рассмотрены методы
аудита информации, получаемой при проведении горно-экологического
мониторинга в горной промышленности.
Ключевые слова: аудит, горное предприятие, экспертиза, окружающая среда.
KULIKOVA E.YU.
ESSENCE, TYPES AND PURPOSE OF ENVIRONMENTAL AUDIT WHILE MINING
This
article is devoted to the types of environmental audit and its
characteristics in terms of the subsoil use. The main stages of the
ecological and geoecological audit of mining enterprise are described.
Review of the methods of audit of information obtained during conducting
of mining and environmental monitoring in the mining industry.
Key words: audit, a mining enterprise examination, environment.
СМИРНОВ В.И., ШУПЛИК М.Н., ВАКУЛЕНКО И.С.
ПРАКТИКА И ПЕРСПЕКТИВЫ СТРОИТЕЛЬСТВА ПОДЗЕМНЫХ ХРАНИЛИЩ ЖИДКИХ УГЛЕВОДОРОДОВ В ВЕЧНОМЕРЗЛЫХ ПОРОДАХ
Показано,
что для герметизации подземного резервуара в период эксплуатации
хранилища на внутренней поверхности выработок — емкостей необходимо
намораживать ледяную облицовку. В практике нашел применение способ
намораживания ледяной облицовки путем заполнения всего объема выработок
пресной водой с выдержкой ее в течение расчетного времени и откачкой
незамерзшей воды при достижении ледяной облицовкой проектной толщины.
Установлено, что оттаивания и разрушения вечномерзлых пород окрестности
выработок не происходит, если скорость подвода тепла к поверхности
теплообмена не превышает способности мерзлых пород отводить тепло вглубь
массива. Исходя из этого условия, разработаны методики расчета
максимально допустимых температур воды и топлива по условию сохранения
породы в твердомерзлом состоянии (формулы 1 и 2).
Проведенные
комплексные исследования, строительство опытных и промышленных хранилищ в
вечномерзлых породах позволяют осуществлять строительство подземных
хранилищ жидких углеводородов в вечномерзлых породах в восточном секторе
Арктики, на нефтяных и газовых месторождениях севера Тюменской области и
Красноярского края, а также в Якутии и других районах Крайнего Севера.
Ключевые слова: подземное хранилище, вечномерзлые породы, жидкие углеводороды, тепловое воздействие.
SMIRNOV V.I., SHUPLIK M.N., VAKULENKO I.S.
PRACTICE AND PROSPECTS FOR CONSTRUCTION OF UNDERGROUND LIQUID HYDROCARBON STORAGES IN PERMAFROST
Quick
pace of the industrial advance in the Far North results from the
acceleration of mining operations at the largest mineral deposits.
Reliability
of handling and distribution systems for liquid and gaseous
hydrocarbons in the areas of the Far North is only achievable through
holding of oil products in storages with sufficient volume to meet
annual demands for a given oil product.
The Far North territory,
with lumped mining of nearly all gas, oil, nonferrous metals and gold in
Russia, has the wide-spread and thick cover of dispersed permafrost
suitable for construction of underground support-free storages.
Russia
has the developed technology and hands-on experience of constructing
and operating the underground storages of liquid hydrocarbons in
permafrost.
The author shows that sealing of an underground storage
during operation requires freezing of ice jacketing on inner surface of
the storage.
The practically applied technique of the constructed
ice jacketing consists of feeling the underground storage with fresh
water, holding the water for a design time period and then pumping out
of unfrozen water when the ice jacket has reached design thickness.
It
has been found that permafrost surrounding such storages does not melt
and fail if the thermal input rate at the heat transfer surface is not
higher than the capacity of the permafrost to spread depthward.
Based
on this condition, the calculation procedures for maximum allowable
temperatures of water and fuel are developed under condition of the
ever-frozen state retention (formulas 1 and 2).
The comprehensive
research and practical experience of pilot commercial storage
construction in permafrost confirm feasibility of underground liquid
hydrocarbon storage construction in ever-frozen subsoil on the east of
the Arctic Region, at oil and gas reservoirs on the north of the Tyumen
Region and Krasnoyarsk Territory as well as in Yakutia and other regions
of the Far North.
Key words: underground storage, permafrost soils, liquid hydrocarbons, thermal effects.
ФЕДУНЕЦ Б.И., БОЙКО Ф.А.
ПОВЫШЕНИЕ ЭФФЕКТИВНОСТИ СТРОИТЕЛЬСТВА ПЕРЕГОННЫХ ТОННЕЛЕЙ МЕТРОПОЛИТЕНОВ ТОННЕЛЕПРОХОДЧЕСКИМИ МЕХАНИЗИРОВАННЫМИ КОМПЛЕКСАМИ
Повышение
эффективности строительства перегонных тоннелей метрополитенов можно
достичь при широком применении конвейерного транспорта разработанной
породы ТПМК, взамен существующего в отечественной практике рельсового
транспорта. Приводится методика расчетов для конвейерного транспорта и
показан положительный эффект от его применения. Отражен экономический
эффект ускорения строительства перегонных тоннелей
Ключевые слова: эффективность строительства, перегонные тоннели, конвейерный транспорт.
FEDUNETZ B.I., BOYKO F.A.
INCREASE OF EFFICIENCY OF BUILDING DRIVING TUNNELS OF UNDERGROUNDS WITH TUNNEL BORING MACHINES
Increase
of efficiency of building driving tunnels of undergrounds can be
carried out with wide application of conveyor transport for developed
breed with tunnel boring machines, instead of rail transport existing in
domestic practice. The technique of calculations for conveyor transport
is resulted and the positive effect from its application is shown.
Economic benefit of carrying out building acceleration of driving
tunnels is reflected.
Key words: efficiency of building, driving tunnels, conveyor transport.
ФРАНКЕВИЧ Ж.А.
ОЦЕНКА ЭКОНОМИЧЕСКОГО УЩЕРБА В ПРОЦЕССЕ ЭКСПЛУАТАЦИИ ПОДЗЕМНЫХ СООРУЖЕНИЙ
Предметом
работы является определение вероятностной величины экономического
ущерба, возникающего в процессе функционирования подземных
коммуникационных тоннелей. Цель заключается в проведении оценки периода
эксплуатации системы коммуникационных тоннелей с точки зрения
экономической эффективности. Оценку периода эксплуатации подземных
сооружений предлагается проводить как с учетом технических, так и
экономических рисков с определением вероятности величины ущерба от их
наступления. Ожидаемая величина экономического ущерба оценивается с
учетом цены транспортировки единицы ресурсов по тоннелю; издержек по
транспортировке единицы ресурсов; уменьшения объемов транспортировки
ресурсов при наступлении отказа; периода восстановления тоннеля; затрат
на восстановление тоннеля; компенсационных выплат предприятиям, у
которых ухудшились экономические показатели; платы, возмещающей
экологический ущерб; вероятности наступления отказа. Для обоснования
экономически эффективного срока эксплуатации подземных объектов
предлагается проводить сравнение величины их остаточной стоимости и
ожидаемого экономического ущерба.
Проведенные исследования
показывают, что с точки зрения экономической эффективности срок
функционирования подземных коммуникационных тоннелей значительно меньше,
чем с учетом технических возможностей. Таким образом, доказана
необходимость проведения оценки периода эксплуатации системы
коммуникационных тоннелей по экономическим показателям, учитывающим
изменение величины вероятного ущерба с увеличением срока эксплуатации
подземных сооружений. Результаты проведенного исследования могут быть
использованы для экономической оценки периодов эксплуатации тоннелей и
других подземных горных выработок.
Ключевые слова: подземные
сооружения, горное производство, затратно-прибыльное исследование, срок
эксплуатации, экономический ущерб, риски, экономическая эффективност